25/03/2024 17:23:49

Sensor - Occupant Classification - Front Passenger’s Seat - Calibration

Correction Code 20204303

Informational PurposesAn informational icon, calling your attention
Note
Any service performed on a seat assembly with an occupancy sensor must be followed by a calibration procedure.
Informational PurposesAn informational icon, calling your attention
Note
In the event of an airbag or seat belt tensioner deployment, certain airbag and seat belt components must be replaced, and other components must be inspected for damage. Refer to SRS Inspection and Component Replacement for a specific list of items that must be inspected and replaced.

Procedure

  1. Set the vehicle climate control to 68 degrees F (20 degrees C).
    Informational PurposesAn informational icon, calling your attention
    Note
    The cabin temperature must be approximately 68 degrees F (20 degrees C) to properly calibrate the sensor.
  2. Set the RH 1st row seat heater to level 1.
  3. Check that the vehicle firmware is at least 2019.40.50 or later. If it is not perform a firmware update. See Firmware Update.
  4. Enable service mode. See Service Mode.
  5. Connect a laptop with Toolbox 3 to the vehicle. See Toolbox 3 (Connect and Disconnect).
  6. Unlock the vehicle gateway. See Gateway Unlock.
  7. Make sure that the key fob is in the vehcle and that nothing is sitting on the RH 1st row seat.
  8. Depress the brake pedal and hold up on the signal stalk together for 10 seconds.
  9. In Toolbox, click the Actions/Autodiag tab, type "OCS-CALIBRATE" in the search field, click on PROC_VCSEATP_FRONT-PASS_OCS-CALIBRATESearch for routine in ToolboxLow Voltage / Seats - Calibrate OCS, and then click Run.
  10. Allow 2 minutes for the calibration rountine to complete.
    Warning IconA warning icon, calling your attention to a possibly risky situation
    CAUTION
    Make sure that there is nothing on the RH 1st row seat.
  11. Disconnect the laptop with Toolbox 3 from the vehicle. See Toolbox 3 (Connect and Disconnect).
  12. Verify that the text "PASSENGER AIRBAG OFF" is displayed in the upper right corner of the touchscreen.
  13. Disable service mode. See Service Mode.
  14. Return the seat heater and climiate control to their previous settings.